allison 2500 transmission fluid capacity

You shouldnt cheap out on good quality oil or fluids too. 2500 & 3500 Double Cab Short Bed: 29.4 Gallons . For the on-highway driving, you have about 20 brands to choose from. But this promise doesnt end after the transmissions are sold. (Refund), Allison 3000 Transmission Fluid Capacity (Oil Type and Tips), Can You Turbo a Ford V10? Run the engine until the transmission fluid reaches the operating temperature of 160 to 200F (71 to 93C). Park the vehicle on a flat, level surface. Luckily, this can be addressed by following the proper L5P Duramax Maintenance schedule. I really doubt the A/T fluid needs changing unless you see evidence of contamination in the fluid. The charts listed below are based off of GMs recommended L5P Duramax Maintenance and Service schedule. Listed below are GMs recommended maintenance schedule for trucks that are driven under normal conditions. If only fluid and filter were changed, add 5.0 L (10.6 pts.) Do not mix types and brands of fluid, because of possible incompatibility. Operating a transmission with the fluid level higher or lower than recommended can result in transmission damage. #1. 7200 Ertel Lane 0000008717 00000 n The synthetic fluid is designed for the big rigs that haul more tons of dirt, etc than a tank weighs. It will take about 30 - 90 minutes depends on your skill level and might save you up to $200 depends on the region you live in. There are two different Allison 1000 transmissions in operation. Good maintenance habits help prevent costly repairs and they do not take up a lot of time. But not all of this fluid is in the transmission pan. Manuals; Brands; . https://www.youtu. The 4 speed has a capacity of 13.5 US quarts while the 5 speed has 12.7 US quarts. Specifications - ALLISON 2500. For more instructions on adding fluid or oil to your truck, see your L5P Duramax owners manual. Is 2.46 us quarts of oil. 0000580844 00000 n As fluid temperature increases, so does the fluid level. These links are affiliate links. The latter is 14.8 and 10.6 respectively. Transmission: Fluid capacity: Fluid type: . You also have to be concerned about power steering fluid, brake fluid, and also transmission fluid. With the vehicle on a level surface and the transmission in neutral at operating temperature, perform the steps below. Deep pan 3 quarts more than shallow pan. I'm at 9qts. Although we can use the DEX-IV it's an Allison transmission, and we should use what Detroit Diesel covers though warrant. So I called the local Chevy dealer who said 7.4 qts. May 29, 2009. 8. That may be so or it may not be so but those words come straight from Allison. If You're wondering what type of fluid to use, then it is DEXRON-Ill Automatic Transmission Fluid. There are two fluid levels when it comes to Allison 3000 transmissions. Maximum output shaft speed at 105 km/hr (65 mi/hr): 4500 rpm. The 2000 Series transmission is designed for commercial trucks and smaller buses with gross weights up to 15,000 kilos (33,000lbs). 12 L. Without special equipment it is possible to replace only ATF in the AT pan because of the way automatic transmission in 2009 Chevrolet Silverado 2500 HD has been designed. 19. This option you should not have to worry about. Under severe you are looking at needing a change at 75,000 and 12,000 miles. Fluid Capacity Specifications Allison 1000. 0000004865 00000 n (Helpful Guide), What Is Freightliner J1587 Code? It is best to stick to the top brands when it comes to your transmission. The Duramax 6.6L turbo-diesel engine is one of the leading diesel engines. Example: oL HI 1 indicates 1 quart of fluid above the full "1" transmission level. Filling above the COLD RUN band when the transmission is below normal operating temperature may result in an overfilled transmission, which causes fluid foaming and aeration. How to Service a Transmission on a 2014 Chevy . Range Inhibit Indicator. Verify that the vehicle is parked on a level surface. ]L #%XxD]Hs5qEXp`@&%DkC'GO,18L[] RH,fKvM]514|=u`HlMh *(~4V_nI.M)z@ M1lM0jX[+rLi"yH0)`P6.,rhl\G[YL%%O ^2d^hTa$`@F}&;0X* PM[q}Fm. If they are honest, and not all mechanics are, then you should get the capacity plus information on good transmission fluid brands even if they are not famous. 1800 miles, The Best Mail Services For Full-Time RVers, The 10 Best Spring Break Destinations For RVers, What You Should Know About RV Towing Insurance, 4 Embarrassing Things We Did As New RVers, Visit Copano Bay RV Resort On The Texas Gulf Coast, Currently Active Users Viewing This Thread: 1. They built the transmission and they will have the best answer for you. Its content provides you with important information when your RV is equipped with an Allison 3000 transmission. Dex-VI does not appear to be on that list of fluids. Diagnosis. Marketing & Dealer Support, Unearthed Magazine Auto Allison Fluid and Filter Change (M74) 7.0 liters. See. Check and adjust the fluid level using the procedures under "Checking the Fluid Level". 0000002369 00000 n JavaScript is disabled. 0000008059 00000 n The explanation for this situation is that since the transmission has been sitting idle, more of the old fluid drained down into the pan. What we find interesting in both categories is that the brand name does not matter. Yeah will Definitley help when I forget again.lol. You shouldnt try and see how long you can go without changing your oil or replacing your fuel filters. Fax 713.466.9839 As I've had the dealer change the fluid when I bought the truck in 2015, it's the first time for me changing the tranny fluid/filter. When you refill the transmission with fluid, it should only handle about 10.6 quarts or 10 liters. Used Parts Servicing Now, I'm here to help with any questions you might have about Allison transmission fluid recommendations, TranSynd, filtration, DEXRON-III, DEXRON-VI, engine oils, oil analysis, etc. Hello paige farrar: Depending on the transmission the fluid and capacity is as follows. Safe operating level is within the HOT RUN band on the dipstick. There are 3 main problems related to valve bodies of Allison 1000/2000/2400: 1. As such, there is some "head room" in terms of power capacity. 0000012695 00000 n The standard sump pump on the Allison 1000 transmission takes 14.8 quarts or 14 liters of fluid on the initial fill. They work on these transmissions and know exactly what they need. If you want that capacity in liters, then you are looking at 28 liters for the deeper pan and 25 for the shallower or regular pan. Ten-bolt, 1 o'clock and 8 o'clock positions (as viewed from rear) PTO drive gear ratio. I don't know if this has changed from previous models to your 2015. I was the former Transmission Fluids Engineer at Allison Transmission from 1990-2009 when I retired. This is correct, thats why it's a full synthetic blend now and covers TES 668/295. It is a quirk but the gearing seems to have a forgetful memory when new fluid is put into the pan. Sign In Upload. They should have the specs for all the models they sell and tell you about different top fluid brands you should use. While the deeper pan should only hold 19 quarts. (Gear ratios do not include torque converter multiplication), Copeland International, Inc. If true, then it may be a good thing as you are getting more of the old fluid out of the mechanism and more new fluid inside. Before Starting. In these modern rigs, you just cant put just any transmission fluid into your vehicle. 0000594149 00000 n If you want that capacity in liters, then you are looking at 28 liters for the deeper pan and 25 for the shallower or regular pan. 18. The standard sump pump on the Allison 1000 transmission takes 14.8 quarts or 14 liters of fluid on the initial fill. When you refill the transmission with fluid, it should only handle about 10.6 quarts or 10 liters. (13L) NV5600 - 6.75 Qts. VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. Allison 3000 transmissions can hold approximately 29 quarts of fluid; the larger Allison 4000 can hold approximately 48 quarts. 1. One model has a shallow sump pump and the other has a standard size. With the engine idling, remove the dipstick from the tube and wipe it clean. We have not found any specs for the new TES 668 fluid. Please keep in mind that you should always double check your owners manual or contact GM directly to make sure anything you purchase will work properly with your truck. 19. All Rights Reserved. 73^Vb`0`czZ ck wX endstream endobj 53 0 obj <>/Metadata 50 0 R/Pages 49 0 R/Type/Catalog>> endobj 54 0 obj <>/ColorSpace<>/Font<>/ProcSet[/PDF/Text/ImageC/ImageI]/Properties<>>>/ExtGState<>>>/Type/Page>> endobj 55 0 obj <> endobj 56 0 obj [/Indexed 79 0 R 255 80 0 R] endobj 57 0 obj [/DeviceN[/Black]/DeviceCMYK 81 0 R 83 0 R] endobj 58 0 obj <>stream 0000020018 00000 n The transmission fluid capacity for the 2005 Chevrolet Silverado 2500HD iS7.8 pints for the manual and 7.7 quarts for initial fill and 13.5 quarts for total fill for the 4-speed automatic and 7.4 quarts for initial and 12.7 quarts for total for the 5-speed automatic. Has a little Power Takeoff. On both web pages linked above, there is a lit of recommended brands you should be using. CHECK TRANS Light. While sometimes maintenance can be expensive, its worth the investment. Allison 3000 Transmission Fluid Capacity. 0000010115 00000 n I have a 2001 2500HD with the 8.1 liter and Allison transmission. When the valve sticks TCM detects that the pressure sensor doesn't change the status and sets the trouble code P0872- after that the gearbox switches to the failsafe mode. Check out the charts below to determine when you need to perform regular maintenance tasks on your L5P. Please support our sponsors and let them know you heard about their products on iRV2. The capacity has not changed in the last few sentences. It doesn't matter. LML Silverado 2500HD & Sierra 2500HD Towing. Includes standard integral damper which is operational in lockup. SOURCE: Fluid Capacity for Transmission. But that amount is not that much and equals roughly 1 pint. With the shallow sump pump, you can expect to put in12.7 quarts or 12 liters the first time. Take the time to do some research to make sure you know how to properly maintain this piece of vital equipment. The transmission shift selector display screen will display one of the following messages. TYPE:One stage, three element, polyphase. . Careers / HR This is one RV part that you cannot cut corners as you will be caught in very difficult situations if you do try to cut corners. All times are GMT-8. The first is to check your owners manual to see what the manufacturer says. Acceptable full-load engine governed speed: 2200 - 3800* rpm. While our guide will give you the manufacturer's recommended fluid capacity for the L5P Duramax, you always need to check your dipsticks and tank levels. Transmission Fluid Filtration. All of these products are listed with links to purchase them. Subscribe to our mailing list, Help Centre The capacity has not changed in the last few sentences. Nov 6, 2014. If the fluid level is within the COLD RUN band, the transmission may be operated until the fluid is hot enough to perform a HOT RUN check. 2. 6-Speed Transmission Allison: Initial Fill 7.0 L (7.4 qt) AF6: . Plus, it is the approved synthetic fluid for all of its transmission series between 1000 and 4000. Properties Of Advanced Automatic Transmission Fluid. If you use Dexron-VI or other transmission fluid, you are looking at 12,000 to 50,000 miles or 500 to 2000 hours of operating time. The Duramax 6.6L turbo-diesel with Allison Transmission, such as in the Silverado, has the best towing capacity and excellent . With 8 cylinders, it produces enough power and torque that could tow a considerable truck. If the transmission was completely overhauled or the torque converter was replaced or drained, add 7.7 L (16.3 pts.) You might have to change them earlier than GMs recommended service intervals. Off brands may be cheaper but the lower cost may only help your budget and not the transmission. Theyre very powerful and capable, but theyre also very vulnerable to poor fuel quality. The former takes 12.7 quarts on the initial fill and 7.4 quarts on the refill. 0000003608 00000 n The newer transmission fluid has some long life, not like 30+ years ago. One has a little sump pump, while the other has a standard-sized one. The recommended type is synthetic gear oil with GM part number 12346190 for the manual and Dexron VI for the 4 and 5-speed . While our guide will give you the manufacturers recommended fluid capacity for the L5P Duramax, you always need to check your dipsticks and tank levels. I spoke to a mechanic at the GM dealership and he suggested . Capacity (Quarts) Suggested Fluid(s) Engine, with filter: 10.1: Chevron Delo 15W-40 Diesel Oil: Cooling System, Initial Fill: 24.4: Dex-Cool: Automatic Transmission, 1000 Initial fill: 7.4: Transynd Synthetic Transmission Fluid: Automatic Transmission, Allison 1000, Total Fill: 12.7: Transynd Synthetic Transmission Fluid: Differential, 8.25 . The HOT RUN band is between the HOT FULL and HOT ADD marks. Engine, Transmission, Front and Rear . 0000019224 00000 n | Our Privacy Policy | Web Design by Green Matchbox, Comprehensive 6.6L L5P Duramax Maintenance Guide, Diesel Resource | Your go-to diesel experts, Fluid Capacity & Recommendations for the L5P resource, 5 Convenient Features of the 2020 L5P Duramax, Build Your Next Super Duty 6.7L Powerstroke, 11 Common 6.6 LLY Duramax Problems And How To Fix Them, 2.8L LWN Duramax Specs, Tow Ratings, and Fuel Economy, 3.0L LM2 Duramax Specs, Fuel Economy, and Towing Capacity, 5 Best 6.6L L5P Duramax Performance Upgrades, 6.6L L5P Duramax Specs, Tow Ratings, And Model Year Changes, 6.6L LB7 Duramax Specifications And Information, 6.6L LLY Duramax Specifications & Information, 6.6L LML Duramax Specifications and Information, Comprehensive 2.8L LWN Duramax Maintenance Guide, Comprehensive 6.6L LBZ Duramax Maintenance Guide & Parts List, Comprehensive LML Duramax Service Schedule, LB7 Duramax Maintenance Schedule, Fluid Specs, And Parts, The Ultimate 6.6L LLY Duramax Maintenance Guide & Service Schedule. If you have a standard transmission the fluid to use is GL 4 gear oil. 19. Initial Fill : 12.0 liters (12.7 qts) Refill : . Drain and fill 5 & 6 speed Allison 1000 & spin on 7.4 Quarts. Its a promisea promise to engineer the highest quality transmissions in the world. 0000001550 00000 n (Helpful Guide), What Is Freightliner J1587 Code? The PPE deep transmission pan adds an extra four quarts of fluid capacity. HIg FLUID LEvEL - "oL" is displayed ( represents "Fluid (Oil) Level Check Mode") followed by "HI" ("HI" represents "High Oil Level") and the number of quarts the transmission fluid is overfilled. Our News DmaxStore has put together this great package for our members to correctly service their Allison transmission. LinkedIn Do not fill above the COLD RUN band if the transmission fluid is below normal operating temperature. Marvin the Mechanic. The transmission fluid ensures that Your cars vital components stay lubricated to provide You with optimum performance and maintenance. View online or download Allison transmission 2500 RDS Service Manual. We cover brake fluid, differential gear oil, transfer case fluid, steering fluid and more. For a fluid change, it is between 75,000 to 150,000 miles or 3,000 hours of operating time. Do not use fluid additives, friction modifiers, extreme-pressure gear fluids, or multiviscosity lubricants. (Data Link Troubleshooting), How Many Quarts Of Transmission Fluid Does An Allison 3000 Take?, Allison 3000 Transmission Fluid Capacity, How Often Should You Change The Allison 3000 Transmission Fluid?. Here is some helpful specs from a different forum article that will cover gas trucks as well as the 6.6, its all useful information. Free 800.966.9860. 1 o'clock position: 1.00 x engine speed. These kits provide the correct amount of fluid and spin on external filter for 2001-2019 Duramax diesels using standard Allison transmission pans. This fluid option is the next generation and the upgrade over the TES 295 version that has been used by Allison successfully for 20 years. All the information we published came from their website. 10.56 UK qt. Those two sets will be briefly mentioned below: Allison has developed, or someone has, a synthetic fluid that is perfect for their transmissions. Posted September 23, 2011. Depending on your driving conditions etc. DRIVETRAIN INTERFACES. extended fluid and filter change intervals are only allowed with an allison approved tes 295 automatic transmission fluid and allison high Capacity Filters. They will also recommend a good transmission fluid brand for you to use. What are the fluid capacities for a 2004 Chevrolet 2500HD 6.6l Diesel? The charts and calculator we provided will be a great help to you. Release the arrow keys and wait for a two-minute countdown. If You want to know what the transmission fluid capacity is on the 2003 Chevrolet Silverado 2500HD, then look no further. Thanks for that always trying to find specs. Remove the dipstick tube cap. Automatic to drain and refill using Dexron type 3 fluid. It was designed to replace the older four-speed automatics . The key will be for you to use the right transmission fluid. 0000575960 00000 n Duramax Fifth Generation: 2011-2016 (LML), https://my.chevrolet.com/content/darado HD & Sierra HD-Duramax-Diesel-Manual.pdf, http://www.dieselplace.com/forum/6341097-lml-faq-frequently-asked-questions.html, Duramax First Generation: 2001-2004 (LB7), Duramax Second Generation: 2004.5-2005 (LLY), Fuel System, Air, Exhaust & Emissions Upgrades. But I do need to know the capacity for the shallow pan with both filters. The filters should be changed sooner than those figures with a respective 75,000 and 25,000 miles under general conditions. 0000019075 00000 n This link gives you all the information you need, including parts numbers, fluid capacities, and so on. This is the basic transmission found in Chevy and GMC 2500HD and 3500HD trucks from 2001 onward, as well as some 1500HD trucks. Finance & Leasing, International Parts If the fluid level is not within the HOT RUN band, add or drain fluid as needed to bring the fluid level within the HOT RUN band. Only Allison Approved transmission fluids are formulated for the unique components of an Allison Automatic. PTO mounting pads. If your running MAG-HYTEC trans pans its brings the total capacity to 10 1/2 qts, the Allison deep pan brings the total to about 10 qts and the rear diff cover brings the total to 8 qts. The DEXRON VI improves and maintains the performance of older GM vehicles. 0000018484 00000 n Careers m). #4 of our Maintenance & Care video series. 0000020153 00000 n On a overhaul the amount is 7.3 us quarts. Much is contained in the transmission cooler, cooler lines, and torque converter. Taking care of your transmission is not difficult and in doing so you are also taking care of your family. In this case, you may see an additional 2 or 3 quarts put inside the pan. Do not overfill the transmission. After some research it was determined that it should have the manual trans fluid in it. (TPO Roof Sealant), What Is The Cummins Fault Code SPN 3031 FMI 9? The recommended transmission fluid is the fully synthetic DEXRON ViATF automatic transmission fluid. Click here to see the whole list and you will notice there are several links to click for specific transmissions. 6-Speed Allison Transmission: VIN Identification: (8th Digit of VIN) 8: Displacement: 403 Cubic Inches or 6.6 Liters: . If the fluid level is not within the COLD RUN band, add or drain fluid as needed to adjust the fluid level to the middle of the COLD RUN band. 2023 Copeland Allison Transmissions . I caught all the old fluid and it looked like a lot, so i measured it to see how much and it was damned close to 19 quarts, the listed "capacity" of this transmission. Check the allison manual. Acceptable engine idle speed range (with transmission in drive): 500 - 820 rpm. There is a lot more to car care than you realize. The transmission fluid capacity for the Allison 1000 series transmission is 12 quarts (11.4L). Allison has developed a Fluid + Filter Calculator, which provides change interval information. There are more fluids in your vehicles that you need to be concerned about. 0000013537 00000 n How To Open Pop-Up Camper Without Crank (Raise Broken Pop-Up), 3.31 vs 3.55 Axle Ratio: Difference Between 3.31 And 3.55, What Is the ACTIVE Network Credit Card Charge? It is called TES 668. There seem to be 2 types of Allison 1000 transmissions installed in different vehicles. Allison Approved synthetic fluids provide extended drain intervals and offer thermal and viscosity advantages over conventional petroleum based fluids, as well as other synthetic fluids. The TES 439 option is for all Allison transmission series from 5000 to 9000. Also, of note, Allison transmissions . Fluid foaming and aeration cause transmission overheating and erratic shifting. I use only high quality oils and fluids in my trucks. It is best to check and keep to the schedule so you do not drive with a worn-out filter and risk damaging the transmission. These sources are the same for other fluids as well. (TPO Roof Sealant), What Is The Cummins Fault Code SPN 3031 FMI 9? The Allison Transynd fluid replacement schedule is 150,000 miles OR 4,000 hours OR 48 months whichever comes first for general specs. But there are no guarantees and none are being made here. L5P Duramax Maintenance Schedule & Service Intervals. Take a few minutes to get up to speed on this topic. It all sounds like a lot but RV transmissions are not the same as car or truck transmissions. The standard or regular pan should only hold 17 quarts. Under general conditions, the TES 295 needs to be changed every 48 months or 300,000 miles while the 389 option says 25,000 miles and 12 months. See. Keep it on schedule so that your transmission does not wear out sooner than you want it to. The Allison 3000 may have to re-learn shift points after a fluid change. This practice should help extend the life of your transmission. For all three filters, you are looking at 50,000 miles or 3000 hours of operating time. Operate the engine at idle (500 to 800 rpm) until normal operating temperature is reached. We say that because Allison has its brand of transmission fluid but it is made by Castrol. For a better experience, please enable JavaScript in your browser before proceeding.

Marketplace Homes For Rent By Owner, Where Did Syphilis Come From Llamas, Articles A